majoron
Apprentice
Joined: 12 Oct 2005
Posts: 243
Location: Frankfurt
|
 Posted: Thu Jul 29, 2010 6:20 pm Post subject: raid6 array offline does not go online after disk substituti |
 |
|
Hi,
I have problems with a raid 6 created with 24x1TB disks on an Adaptec 52445. I don't know if this is the correct place to ask this. I hope it is not very wrong...
Description of the problem:
One day I got IO errors when reading and writing data from the partition where the raid is.
I unmounted the partition where the raid was, made some checks and detected that one disk was having problems (#19). I switched off the system and changed the faulty disk. Then I expected to have access to the raid again, but this was not the case: the raid went offline; doing "arcconf GETCONFIG 1 al" (arcconf is the command line utility that adaptec provides) gives:
| Code: | Controllers found: 1
----------------------------------------------------------------------
Controller information
----------------------------------------------------------------------
Controller Status : Optimal
Channel description : SAS/SATA
Controller Model : Adaptec 52445
Controller Serial Number : 8A3510957F1
Physical Slot : 3
Temperature : 65 C/ 149 F (Normal)
Installed memory : 512 MB
Copyback : Disabled
Background consistency check : Disabled
Automatic Failover : Enabled
Global task priority : High
Performance Mode : Default/Dynamic
Stayawake period : Disabled
Spinup limit internal drives : 0
Spinup limit external drives : 0
Defunct disk drive count : 0
Logical devices/Failed/Degraded : 1/1/0
--------------------------------------------------------
Controller Version Information
--------------------------------------------------------
BIOS : 5.2-0 (16501)
Firmware : 5.2-0 (16501)
Driver : 1.1-5 (2456)
Boot Flash : 5.2-0 (16501)
--------------------------------------------------------
Controller Battery Information
--------------------------------------------------------
Status : Optimal
Over temperature : No
Capacity remaining : 100 percent
Time remaining (at current draw) : 1 days, 20 hours, 31 minutes
----------------------------------------------------------------------
Logical device information
----------------------------------------------------------------------
Logical device number 0
Logical device name : todo
RAID level : 6 XOR
Status of logical device : Failed
Size : 20973524 MB
Stripe-unit size : 256 KB
Read-cache mode : Enabled
Write-cache mode : Disabled (write-through)
Write-cache setting : Disabled (write-through)
Partitioned : No
Protected by Hot-Spare : No
Bootable : Yes
Failed stripes : No
Power settings : Disabled
--------------------------------------------------------
Logical device segment information
--------------------------------------------------------
Segment 0 : Present (0,0) 9QJ2FA2X
Segment 1 : Present (0,1) 9QJ30S8S
Segment 2 : Present (0,2) 9QJ2Y5WL
Segment 3 : Present (0,3) 9QJ31R5R
Segment 4 : Present (0,4) 9QJ2QTFL
Segment 5 : Present (0,5) 9QJ2Z52Y
Segment 6 : Present (0,6) 9QJ2Z08D
Segment 7 : Present (0,7) 9QJ2HRCW
Segment 8 : Present (0,8) 9QJ2Z92X
Segment 9 : Present (0,9) 9QJ2WPJE
Segment 10 : Present (0,10) 9QJ2XA9S
Segment 11 : Present (0,11) 9QJ2X9MX
Segment 12 : Present (0,12) 9QJ31JM2
Segment 13 : Present (0,13) 9QJ2TB8K
Segment 14 : Present (0,14) 9QJ2W5CS
Segment 15 : Present (0,15) 9QJ31T6B
Segment 16 : Present (0,16) 9QJ2ZP2B
Segment 17 : Present (0,17) 9QJ2RHT5
Segment 18 : Present (0,18) 9QJ2T687
Segment 19 : Missing
Segment 20 : Present (0,20) 9QJ310QL
Segment 21 : Present (0,21) 9QJ2XA71
Segment 22 : Present (0,22) 9QJ1ZVQK
Segment 23 : Missing
----------------------------------------------------------------------
Physical Device information
----------------------------------------------------------------------
Device #0
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,0(0:0)
Reported Location : Connector 0, Device 0
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2FA2X
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #1
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,1(1:0)
Reported Location : Connector 0, Device 1
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ30S8S
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #2
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,2(2:0)
Reported Location : Connector 0, Device 2
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2Y5WL
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #3
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,3(3:0)
Reported Location : Connector 0, Device 3
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ31R5R
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #4
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,4(4:0)
Reported Location : Connector 1, Device 0
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2QTFL
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #5
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,5(5:0)
Reported Location : Connector 1, Device 1
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2Z52Y
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #6
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,6(6:0)
Reported Location : Connector 1, Device 2
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2Z08D
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #7
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,7(7:0)
Reported Location : Connector 1, Device 3
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2HRCW
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #8
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,8(8:0)
Reported Location : Connector 2, Device 0
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2Z92X
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #9
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,9(9:0)
Reported Location : Connector 2, Device 1
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2WPJE
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #10
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,10(10:0)
Reported Location : Connector 2, Device 2
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2XA9S
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #11
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,11(11:0)
Reported Location : Connector 2, Device 3
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2X9MX
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #12
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,12(12:0)
Reported Location : Connector 3, Device 0
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ31JM2
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #13
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,13(13:0)
Reported Location : Connector 3, Device 1
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2TB8K
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #14
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,14(14:0)
Reported Location : Connector 3, Device 2
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2W5CS
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #15
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,15(15:0)
Reported Location : Connector 3, Device 3
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ31T6B
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #16
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,16(16:0)
Reported Location : Connector 4, Device 0
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2ZP2B
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #17
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,17(17:0)
Reported Location : Connector 4, Device 1
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2RHT5
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #18
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,18(18:0)
Reported Location : Connector 4, Device 2
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2T687
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #19
Device is a Hard drive
State : Ready
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,19(19:0)
Reported Location : Connector 4, Device 3
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2Y3N3
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #20
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,20(20:0)
Reported Location : Connector 5, Device 0
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ310QL
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #21
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,21(21:0)
Reported Location : Connector 5, Device 1
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ2XA71
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #22
Device is a Hard drive
State : Online
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,22(22:0)
Reported Location : Connector 5, Device 2
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ1ZVQK
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Device #23
Device is a Hard drive
State : Ready
Supported : Yes
Transfer Speed : SATA 3.0 Gb/s
Reported Channel,Device(T:L) : 0,23(23:0)
Reported Location : Connector 5, Device 3
Vendor :
Model : ST31000340NS
Firmware : SN06
Serial number : 9QJ303YT
Size : 953869 MB
Write Cache : Disabled (write-through)
FRU : None
S.M.A.R.T. : No
S.M.A.R.T. warnings : 0
Power State : Full rpm
Supported Power States : Full rpm,Powered off
NCQ status : Disabled
Command completed successfully.
|
As you can see both disk #19 and #23 are ready instead of online. Why ready and not online? Why #23, if it seems to be okay when I run the checks on it?
What can I do to recover the data on the raid? Should I force the raid to an online status?
Is any expert there who can help me?
Thanks in advance.
_________________
Computers are like air conditioners, they stop working properly if you open Windows |
|
Kernel & Hardware
